2000 Toyota 4Runner Underbody Shields Problems
- 40
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- frame rusted · 14 records
- rusted through · 11 records
- passenger side · 10 records
- frame rail · 7 records
- side frame · 6 records
- safe drive · 4 records
Mileage in stored records
| Band | Records |
|---|---|
| 150–400k mi | 16 |
| 100–150k mi | 15 |
| 60–100k mi | 2 |
Complaint records
Owner-submitted complaint content, presented as stored.
Suspension · Underbody Shields
Upon removing and replacing my exhaust and muffler on our 2000 4runner limited i spotted a hole in my frame on the rear passenger side just before my right passenger wheel and suspension. I finished installing the new exhaust an began inspecting the frame along the length of the vehicle. While the truck is not new ...it only had what appears to be limited surface rust to most of the framework. However , the portion…
ODI 10713084
Frame And Members · Underbody Shields
Tl* the contact owns a 2000 toyota 4runner. While the vehicle was being serviced by an independent mechanic, it was discovered that the passenger side frame was rusted on both sides and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 135,600. Updated 6/24/15*cn
ODI 10714396
Underbody Shields
Submission from constituent re 2000 toyota 4-runner safety & environmental issues concerns [toyota motor sales]. *smd the consumer stated the frame on his vehicle is rusted, to the point where the vehicle is not safe to drive. The frame rail is exhibiting corrosion to the point where sections of the frame have completely disintegrated leaving him with major holes and welded suspension mounting components completely…
ODI 10705725
Suspension · Underbody Shields
The frame on out 2000 toyota collapsed because of rust. The collapse was on the side frame rail, just before the drivers side rear wheel. The vehicle is not able to be driven. *tr
ODI 10700968
Underbody Shields
Went to my mechanic for an full exhaust repair and was told that the vehicle had frame rot so extensive that the repair should not be done, and that in fact the car was unsafe to drive. There was a recall on this frame for the tacoma and the tundra as well, and there should be one on this generation of 4runner. I have a 1989 4runner with 250k miles and no such issues with frame rot. Now i'm out thousands of dollars…
ODI 10659327
Underbody Shields
Frame is rusted through. Toyota has recalled frames for tacomas and tundras but not 4runners 4runner is built on same frame as tacoma. Why no recall? *tr
ODI 10652287
Underbody Shields
I brought my vehicle to a repair shop for inspection because the vehicle was not riding safely. They found extensive rust and corrosion on the back under carriage of the frame of the car posing a potential safety and road hazard. It was not normal wear and tear. I don't have the vin number yet to post because the vehicle is in the shop to be repaired. *tr
ODI 10650848
Underbody Shields
Took 2000 toyota 4runner sr5 in for inspection. My independent mechanic said frame is bad. Frame is severely rusted and has multiple holes on passenger side rear wheel area in both the front and back of this area. It also has severe rust and holes in the frame on the driver side in the same rear area and above the gas tank on the driver side. Vehicle is considered unsafe because of the damage to the frame. Spoke to…
ODI 10632801
Suspension · Underbody Shields
I purchased my 2000 toyota 4 runner one year ago at dry ridge toyota used cars. While driving the vehicle, the vehicle began shaking in the rear end from side to side on the highway at any speed. It was difficult to control the vehicle with the side to side rear end wobbling which was visible from vehicles following behind. Upon having the vehicle checked out at a garage and put up on a lift, the frame underneath…
ODI 10630161
Underbody Shields
I took my 2000 toyota 4runner limited to my local mechanic for the annual ny state inspection. This is a one owner (me) vehicle with only 126,777 miles. What he found was extensive rust and perforations on the passenger side frame from front to rear. He told me that it was not repairable and that it is a safety concern. He said we were lucky not to have experienced a complete collapse and failure in that section…
ODI 10630722
Underbody Shields
Took the vehicle in for regular service (oil change, tire rotation, etc.) and was informed that the frame had rusted through in several areas. They recommended taking the vehicle to a toyota dealer since extreme rust problems have been a recurring problem with toyota trucks & suvs. Looking online, i saw recalls for the rust problems with trucks, but no recall for 4runners??? I think there should be the same…
ODI 10621894
Underbody Shields
Tl* the contact owns a 2000 toyota 4runner. The contact stated that while driving at various speeds, a loud noise was heard underneath the vehicle. The contact noticed that the main frame underneath the vehicle was rusted and had holes. The vehicle was not taken to a dealer but was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 180,000.
ODI 10732102
Suspension · Underbody Shields
The vehicle frame is deteriorating from rust on the passenger side of the vehicle. This severe rust is prevalent at suspension attachment points; significantly where the right-side rear "track bar" is attached. If this were to fail, the rear axle of the vehicle would become disconnnected from the vehicle undoubtedly causing a crash. Found out tonight the frame rail forward of the track bar has also deteriorated on…
ODI 10606353
Suspension · Underbody Shields
I am writing to report a defect in the frame of my 2000 toyota 4runner. I just purchased this vehicle used for my 16 year old daughter to drive. Inspection by a certified mechanic revealed that the frame exhibits extensive rusting. The frame has rusted through on the passenger side between the front and rear wheels. It has holes and has separated along the bottom weld. The mechanic warned that catastrophic failure…
ODI 10595363
Underbody Shields
Severe rust on passenger side of frame unsafe will not pass inspection. *tr
ODI 10578651
Underbody Shields
Rusted out frame. I took my truck in for some minor repairs. The shop called me back and said the frame is so rusted that the car is no longer safe to drive.. The support holding up the transmission is about to break. This could've caused a serious accident or worse if it happened while i was driving.. Not to mention i don't have the money to just buy a new car on a whim.. Unfortunately i will have to continue…
ODI 10564512
Suspension · Underbody Shields
Frame is rusting through causing instability concerns. *tr
ODI 10555720
Structure · Suspension · Underbody Shields
2000 toyota 4runner frame rusted threw at area that holds rear axel in place rear drivers frame rail had rusted through where it mounts the lower control arm. When frame failed vehicle was hard to control and swaying to the point of immediate danger to passengers and other vehicles on highway this vehicle is well maintained and is in excellent condition. Frame failure on this age vehicle should be unacceptable and…
ODI 10553553
Suspension · Underbody Shields
Frame rusted in front of both rear tires load bearing area. Toyota refuses any warranty or acknowledgement of this safety problem on truck frames used on suv's. Tacoma frames all recalled for same reason. Toyota still states not to undercoat when purchase is new or to rust prevent at any warranty/preventive maintenance inspection. Consumer put at risk to a problem only observable from a lift,and told to spend…
ODI 10544132
Underbody Shields
Frame rusted through. Will not pass state inspection. *tr
ODI 10532736
Underbody Shields
2000 toyota 4runner was in for scheduled routine maintenance. At this time, it was reported that the vehicle's frame is cracked and not safe to drive. The vehicle was then looked at by a local welder who confirmed the cracked frame and reported excessive frame corrosion. *tr
ODI 10533496
Fuel System, Gasoline · Suspension · Underbody Shields
While having my 2000 4runner serviced recently, my mechanic advised me that my carriage frame was cracked and rotting. I took it to toyota dealer in bristol ct, who put vehicle on hoist and confirmed the problem. I was advised there was no recall or tsb on my suv, and probably nothing they could do. They said they would send info & pictures to district office for review and advise when they heard back. I asked them…
ODI 10526087
Underbody Shields
Frame rot. Right side along rear wheel. Crack in the frame. Otherwise frame fine and no rust/rot on left hand side. *tr
ODI 10519544
Underbody Shields
Replacing the muffler and was informed by the mechanic that the frame is rusted through. Should not have happened. Needs recalled. *tr
ODI 10504813
Underbody Shields
My mechanic informed me that my well maintained 4runner has holes in the frame from rot and is junk. The rest of this vehicle is in beautiful shape. I am really upset. *tr
ODI 10499885